Wilbur Curtis TCC1C Bruksanvisning

Wilbur Curtis ej kategoriserat TCC1C

Läs gratis den bruksanvisning för Wilbur Curtis TCC1C (12 sidor) i kategorin ej kategoriserat. Guiden har ansetts hjälpsam av 3 personer och har ett genomsnittsbetyg på 3.7 stjärnor baserat på 2 recensioner. Har du en fråga om Wilbur Curtis TCC1C eller vill du ställa frågor till andra användare av produkten? Ställ en fråga

Ladda ner PDF
Sida 1/12
NSF International requires the following water connection:
1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so that the machine
can be moved for cleaning underneath.
2. Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicable
federal, state and local codes..
3. Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized,
installed and maintained in accordance with federal, state, and local codes.
1
Important Safeguards/Symbols
Service Manual, TCC
Thisapplianceisdesignedforcommercialuse.Anyservicingotherthancleaningandmaintenance
shouldbeperformedbyanauthorizedWilburCurtisservicecenter.
•DoNOTimmersetheunitinwateroranyotherliquid
•Nevercleanwithscouringpowders,bleachorharshchemicals.
Symbols:
WARNINGS – To help avoid personal injury Important Notes/Cautions
Sanitation Requirements
Curtis TCC Units are Factory Pre-Set and Ready to Go… Right out of the Box.
Generallytherewillneverbeareasontochangefactorysettings.However,shouldyouneedto
makeslightadjustmentstomeetyourteaneeds,adjustmentinstructionsareprovidedlaterinthis
manual.
SystemRequirements:
•WaterSource30–90PSI(MinimumFlowRateof1GPM).Ifincomingwatersupplyisgreater
than90PSI,additionalregulationisrequiredtomeettherange.
•Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbe
sized,installedandmaintainedinaccordancewithfederal,state,andlocalcodes.
SETUP STEPS
Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connecta
waterlinefromthewaterltertotheTCCserver.NOTE:Sometypeofwaterltrationdevicemust
beusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhardwater,wesuggestthat
asedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyoursystemand
enhanceteaquality.
INSTALLATION
1.Removedispenserfromcarton.
2.Runawaterlinetotheinletttingbehindthedispenser.Flushthenewwater-
line to remove foreign particles.
3.Connecta¼”aredexibleorcopperwaterlinetothemalettingontheback
of the dispenser.
4.Locatethewatersupplyvalvebehindtheunittoverifypositionisturnedon.
CAUTION:Werecommendedthatthewatersupplyvalve,behindunit,beturnedoffduring
non-business hours.
Wilbur Curtis Company, inC.
ModelsIncluded
•TCC1
•TCC2
•TCC3
NOTE:Watersource
pressure must be a
minimumof30PSI
pressure at all times
toinsurethequalityof
the of the product.
5.CleanouttheteaconcentratesystembeforeusingtheTCCserver.UseaBag-in-Box
stylecleaningsolutiontosimplifythecleaningprocedure.AcleanerlikeBevClean
beveragelinecleanercomesina3gallonbag-in-boxthatconnectsdirectlytoyour
bag-in-boxsystemforlinecleaning(http://bevclean.com).
a.Removethequickdisconnectfromtheteaconcentratebag.
b.PlacetheBIBcleanercontainernexttotheTCCteadispenser.Pullthespout
fromthecleanerboxthroughthemarkedarea.Removethecleartravelcapfrom
spout.Don’tworryaboutcleanerspillingwhenthecapisremoved.Thecaphas
an internal seal.
c. SnaptheQCDbagconnectorontothebagspout.
OFF
ON
ISO 9001:2008 REGIS-
TERED
WILBUR CURTIS CO., INC.
6913 West Acco Street
Montebello, CA 90640-5403
For the latest information go
to www.wilburcurtis.com
Tel: 800-421-6150
Fax: 323-837-2410
2
7. Carefullyliftthebagandsetthebagintothedispenser.
8. Resttubingontopofthebag.Routetubingtooppositeproductintake
holeonoorofdispenser(seeillustration,left).
9. Replacethetopcover.
10. Dispensebeveragefromfaucetuntildarkerproductstartstoappear(~5
seconds).
11. TheTCCserverisnowreadytodispensetea.
3. Pullofftheshipping
cap that covers the
spout on the bag.
4. PlacetheQCDnextto
the spout.
5. SlideQCDsideways,
over the bag spout.
QCDsnapsinplace.
6. PushQCDplungerinto
bag spout until plunger
topisushwithtopof
QCD.A“click”willbe
heardwhenitisfully
inserted.
LOAD PRODUCT
Bag-In-Box
1.PlaceateaconcentratebagonthecounternexttotheTCCdispenser.
2. RemovethetopcoverfromtheTCCdispenserandpulloutthehosewiththeQCD
bag connector.
d. Graspingthebagconnector(asshowninLoadProduct,step6),pushtheslidingprobeallthewayintothe
bagspout.A“click”willbeheardwhenitisfullyinserted.
e. Oncethecleaningsolutionboxisconnected,openthedispensingvalveonthedispenserandrunliquid
throughthevalveuntilthesanitizer(clearliquid)isdetected.Thedispensinglineisnowclean.
f. Disengagethebagconnectorbysnappingtheconnectorprobeoutandremovetheconnectorfromthespout.
g. ReattachtheteaconcentrateBIB.
h. Opendispensingvalveondispenseruntilteaowsfreely.
WATER PRESSURE AND MIXING VALVE
Thepressureregulatorshouldrarelybechanged.Primarytaste/brixadjust-
mentsshouldbedoneviathemixingvalvebyturningtherodandtastingthe
nishedproduct.98%ofavoradjustmentsshouldbedoneinthismanner.
The purpose of the regulator is to provide uniform water pressure so the venturi-
stylemixingdevicecanproduceastableanduniformblendofconcentrateand
waterandalsotoprotectthehydraulicsofthedispensingunitfrom“linepres-
sure”.Itisnottheprimaryadjustmentforthebrixlevel.Fromourtesting,ithas
beenshownthatexactPSIonthegagedoesnotdirectlycorrelatetoabrixlevel
from unit to unit and from installation location to installation location.
Secondarily,iftheprimaryadjustmentdoesn’tprovidetheidealbrixlevel,call
CurtisCareforinstructionsonhowtoadjusttheregulator.Asarule,verylittletasteadjust-
ment is achieved via the pressure regulator.
CAUTION: Do Not Exceed 25 psi (static). Equipmentfailureorleakagewill
result.

Produktspecifikationer

Varumärke: Wilbur Curtis
Kategori: ej kategoriserat
Modell: TCC1C

Behöver du hjälp?

Om du behöver hjälp med Wilbur Curtis TCC1C ställ en fråga nedan och andra användare kommer att svara dig


ej kategoriserat Wilbur Curtis Manualer

Wilbur Curtis

Wilbur Curtis TCC3 Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis TCC1C Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis G4STB Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis TCC2 Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis TC-3S Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis GEM-3 Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis G4TB Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis SW-1 Bruksanvisning

25 Augusti 2025

ej kategoriserat Manualer

Nyaste ej kategoriserat Manualer

Draper

Draper Expert 21744 Bruksanvisning

26 September 2025
Samsung

Samsung PS58B680T6P Bruksanvisning

26 September 2025
Electrolux

Electrolux M2GCP121 Bruksanvisning

26 September 2025
Elektron

Elektron Machinedrum Bruksanvisning

26 September 2025
Dinex

Dinex Meals On Command II Bruksanvisning

26 September 2025
SRS

SRS DC215 Bruksanvisning

26 September 2025
Ninja

Ninja Intelli-Sense CT682 Bruksanvisning

26 September 2025
T'nB

T'nB UMCHARGER1 Bruksanvisning

26 September 2025
Samsung

Samsung WA82QAD Bruksanvisning

26 September 2025
Ikon

Ikon ISP72 Bruksanvisning

26 September 2025